Electric Bicycle battery maintenance and fire prevention knowledge

The Electric Bicycle industry has been expanding with the market, and after more than ten years of efficient and rapid development, the development of the Electric Bicycle has now entered a mature stage, and the related applications and innovative technologies have been continuously improved, and the quality of the products has been enhanced accordingly. Next, let's take a look at the battery maintenance and fire prevention knowledge of Electric Bicycle.

Here is the content:

Battery maintenance

Fire prevention

Battery maintenance

After a qualified battery for Electric Bicycle is shipped from the battery manufacturer, the life and performance of the battery depend to some extent on the consumer's use and maintenance.

(1) Matching of charger and battery.

Electric Bicycle with battery is charged badly, not used, it can be seen the importance of matching the charger and battery, here are two cases: one is the new charger itself and the battery manufacturer to provide the parameters do not match, the second is the poor quality of the components of the charger itself, at the beginning of use, it is still a match, with the consumer charging and discharging cycle use, Electric Bicycle charger itself due to temperature rise, components aging, resulting in charging voltage and conversion current drift, the battery was damaged.

(2) Frequent and timely replenishment of electricity.

Consumers usually have a misunderstanding of the cycle life of the manual, that charging once, Electric Bicycle battery life will be reduced once, so each time the battery power consumption to the controller's protection voltage 31.5V before starting to replenish the power, I do not know that this not only does not protect the battery, and shorten the battery life. So remind the majority of consumers, in the case possible, should be timely to the battery to replenish the power.

(3) Is strictly prohibited to continue to ride when the indicator shows Undervoltage. For some consumers riding halfway, the indicator light shows the under-voltage condition, take a break, and then ride a section of the way, this is very harmful to the Electric Bicycle battery, serious over-discharge will make the battery salt or generate lead dendrites, so that the battery short circuit, affecting the life.

(4) Electric Bicycle just starts, climbing, overload should try to help.

(5) When riding Electric Bicycle on rainy days, you should try to avoid getting the switch and connector wet to prevent leakage.

Fire prevention knowledge

Electric bicycles should be checked frequently to prevent contact points from firing and heating due to poor contact; avoid short circuits and series of accidents caused by aging and wear of the line. The electric circuit and protection devices are intact and effective. Electric Bicycle battery charging will run out of flammable gas, so charging must not be in a cramped, sealed environment, and should be done outdoors as much as possible, or the battery should be removed and charged separately. When charging, choose a suitable line, lay the line should be fixed installation, to install short circuit and leakage protection device.

Electric Bicycle charging must be far away from flammable objects, can not be charged for too long, charging time is too long, the charger overheating easily triggered by fire, and charging should be charged by the provisions of the manual, charging time in principle should not exceed 10 hours. When charging, the charger should be placed in a place where it is easier to dissipate heat; if the Electric Bicycle's battery is of poor quality or used for a long time, the temperature of the charger is likely to be very high and cause a fire, so charging at night when sleeping time is not to be taken lightly.

Electric Bicycle in the process of starting, or climbing the slope should be pedaled to help, to prevent the start of the current is too large, the machine overload for a long time, causing motor coils, lines, battery, and governor overheating damage, and even disasters. Try to avoid driving in the rain, on waterlogged roads, to prevent the motor into the water, charging short-circuit fire.

In addition, when buying Electric Bicycle, a lithium battery should be preferred. It has a large capacity, less self-consumption, and less pollution, followed by a lead-acid dry battery, which is well sealed, not easy to leak electrolytes, and must prevent electrolyte leakage caused by pollution, corrosion, and injury. When buying Electric Bicycle, you must read the product manual and operate according to it, and choose the battery that matches the model and specification of the Electric Bicycle, charger, and motor.

The above is about Electric Bicycle's battery maintenance and fire prevention knowledge, if you are interested in Electric Bicycle, you can contact us, our website is https://www.shenyunscooters.com/. We are very much looking forward to your arrival and hope to cooperate with you.